I had asked the dealer at 90,000miles if I should plan on replacing struts soon because I noticed the boots were torn on the struts. The Toyota man said he had never replaced struts on a Prius. Tire man said I had cupping on the rear tires which indicates worn shocks. I had asked the dealer at 90,000miles if I should plan on replacing struts soon because I noticed the boots were torn on the struts. The Toyota man said he had never replaced struts on a Prius. Tire man said I had cupping on the rear tires which indicates worn shocks. That means it's built in Japan. All Gen 2 Prius are built in Japan. That means it has Japanese struts and shocks from the factory. That means the struts and shocks are lifetime units. They typically NEVER need to be changed for the practical life of the vehicle. They will take off your lifetime front brake calipers or struts sometimes they are still in warranty!!! So they are ripping you off two or even three ways at once. Very possibly the same vendor as the Prius, maybe Tokiko. If your strut boot is torn it's possible the car has been wrecked. Sort of unusual for the boot to be torn but not unheard of. It does not mean the strut is near failure either. The only thing that indicates failure on a Japanese strut is large fluid leakage more than a seep. Now when you start talking Japanese cars built in America it's a different story, then it becomes nuance with some of these parts being lifetime and some being earlier failure, it depends mostly on the vendor source. All Gen 2 Prius are built in Japan. That means it has Japanese struts and shocks from the factory. That means the struts and shocks are lifetime units. They typically NEVER need to be changed for the practical life of the vehicle. Very possibly the same vendor as the Prius, maybe Tokiko. If your strut boot is torn it's possible the car has been wrecked. Sort of unusual for the boot to be torn but not unheard of. It does not mean the strut is near failure either. The only thing that indicates failure on a Japanese strut is large fluid leakage more than a seep. I have owned three Prius. The 2001 and 2004 both needed new front struts and rear shocks after 60K miles or so. In the case of the 2001, the parts did not leak noticeably. In the case of the 2004, the right front strut leaked substantial fluid, coating the entire strut body so it was nice and shiny. However, I then started an extended business trip and could not work on the car for a couple of months. After that time, the very thin strut fluid had all evaporated likely due to the hot Arizona ambient summer temps. Hence, although substantial fluid leakage proves the strut is bad, the lack of visible fluid is not proof that the strut is good. The front strut pleated rubber covers tend to rot and fall apart after a while. The car does not need to be in an accident for this to happen. I can accept that many Japanese-built cars have high-quality struts and shocks that will last a very long time. However, being made in Japan is not a 100% assurance of suspension part quality. KYB is the original equipment supplier to Toyota for Prius struts and shocks. I've been working at a large Toyota dealer 25 techs for two years. I've replaced about 2 pairs of struts and have maybe seen another 8 to 10 pairs replaced by other techs. None of them on a Prius. On any given day I work on at least 1 Prius, usually 3 or 4 of them. Lot's of them with high miles, like Taxis with 300K It's possible your problem is a locality issue due to the heat. We don't have that kind of heat in Seattle. I'm also suspect of who is working on your car if it's not yourself. I have seen cars come in from a recent rain or car wash and the area around the strut is the last place to dry and the water looks like oil. It may be problematic to check a strut by hand, unless there is obvious zero resistance when you pull or push. The best test is a bounce test under vehicle weight. You push the bumper real hard up and down a couple of times, two people is better. The car should not continue to bounce when you stop pushing. It should rebound to ride height and that is all. Just talked with one of the parts guys, he has over 15 years at this dealer. He says Prius struts and shocks are a non stocking item, so that means that there are no more than 2 pair sold per year. He says they have always been a non-stocking item and he's only ever ordered about 1 individual or 1 pair per year. I'll admit that I put 50k miles on the tires without ever rotating them and the tire place found that both the rear tires were also out of balance. Anyway, I haven't noticed any change in the ride or any obvious signs of warn shocks. I'll try your bounce method tomorrow. BTW: 105k miles on the prius. Currently, the only things required for the vehicle during that time are wiper blades, tires, and oil. I had to replace the front dash 12v power port only because I blew the fusible link by powering a 280watt inverter so that doesn't really count as a failure or needed maintenance issue. Friggin car is solid. It may be problematic to check a strut by hand, unless there is obvious zero resistance when you pull or push. The best test is a bounce test under vehicle weight. You push the bumper real hard up and down a couple of times, two people is better. The car should not continue to bounce when you stop pushing. It should rebound to ride height and that is all. Failing Granpa's bounce test means the shocks are bad, passing doesn't necessarily mean they are good. The bounce test tests low speed damping in the shock, it doesn't test high speed damping. In simple terms, low speed damping is the ability to control the cars movement at it's natural jounce frequency of approximately 1 Hertz. High speed damping is the ability to control the tires reaction to road irregularities like Botts' Dots, washboard surfaces, potholes, out of balance wheel conditions, poor tire construction, etc. I'll admit that I put 50k miles on the tires without ever rotating them and the tire place found that both the rear tires were also out of balance. Anyway, I haven't noticed any change in the ride or any obvious signs of warn shocks. I'll try your bounce method tomorrow. Could be an alignment issue. Also could be a inflation pressure issue. The high pressure some people run for good mileage is not necessarily the best for optimum wear. Rotating can help as it reduces the time any given tire is on the problem end if it is an alignment problem. My '01 Prius has 325k miles on it, and I have no record that the struts were ever changed. Based on how it handles over bumpy pavement, they definately need to be changed, and will be soon. Perhaps folks with Prii old enough to need new struts don't go to the dealer for that service. If not under warranty, I would never take my car to the dealer for simple non-hybrid system related service such as strut replacement. Also, struts are relatively expensive and bulky items, so I can see why a dealer parts department wouldn't stock them routinely. This is for 2G; Classic is similar except you have to deal with removing the trunk trim instead of the hatch trim. The rear seat cushion pulls up for access to the rear shocks top mounting hardware. That made it really easy for me to decide to DIY. My '01 Prius has 325k miles on it, and I have no record that the struts were ever changed. Based on how it handles over bumpy pavement, they definately need to be changed, and will be soon. I would put it around 250K. After that you would look closer at replacing things like struts and shocks. However unless they are leaking they are generally still good. Like I've said before my '91 Civic is approaching 300K with the original front struts, rear shocks, and front calipers. I've dealt with this issue pretty much my entire career. The aftermarket shops almost always want to replace stuff that doesn't really need it. This is especially true with Japanese built vehicles. American vehicles especially pre 2000 do have 60k struts and calipers, they do need replacement. The AM shops get that mindset and push it on all brands. It gets to be an urban legend. Perhaps folks with Prii old enough to need new struts don't go to the dealer for that service. If not under warranty, I would never take my car to the dealer for simple non-hybrid system related service such as strut replacement. Also, struts are relatively expensive and bulky items, so I can see why a dealer parts department wouldn't stock them routinely. There's always customers that stick with the dealer. We would be seeing some struts if they were actually bad. It's an inspection item on every oil change. Some of the US sourced struts on other models do very occasionally leak, so it's not like we never see bad struts. Parts stock is based on one thing only, sales. No sales, no stock. So you would never go to the dealer for something like struts? Let's say a factory strut lasts 200K. They last longer but just for the discussion. Any industry insider will tell you they aren't, too many loopholes. So you replace those struts 3 times for every time you would replace a factory strut. Where does that end up dollar wise? You should hit the dealer at least once a year even if it's just an oil change. There's a lot of recalls and they are constantly being updated. Things like ECM flashes are lifetime and no charge. And I would always go to the dealer if you have a problem. They are much quicker and more accurate at diagnosis. Right now the 2nd gen Prius is having problems with intake manifolds and the warranty is extended on that problem to 80K. About PriusChat Founded in 2003, PriusChat has been the go-to spot for Prius, hybrid, and EV discussion for over 10 years. PriusChat is the one of the largest privately-owned car forums left on the internet.
